20 Ton H Fire Tube Boiler
When operating the 20 ton h fire tube boiler, what is the "waters"? When the boiler water gauge did not see the water level, wash first with water table method to determine water or with water. If it is determined that water, water level meter for even the highest fire tube boiler is lower than the boundary, emergency shutdown immediately, reducing the furnace temperature, the main steam valve and to close the valve. For larger capacity of water, and the water boiler higher than even the highest fire tube boiler industry, can be "called water" method to determine the severity of water shortages, in order to take appropriate measures. When the "waters" to determine water shortage is not serious, it can continue to the boiler feed water, the water level returned to normal, gradually warming up to start burning equipment, boost operational. Through the "waters", sentenced to severe water shortages, have emergency shutdown, non-blind feed water to the boiler. Never allow chances attempt to cover liability resulting boiler water shortage and water supply blind. This wrong approach often lead to disaster, expansion of the accident, causing the boiler furnace explosion and crash. The method of "waters" are: (1) turn on the water tap open water table. (2) stripping off cock. (3) close the water cock. (4) and then turn on the water tap is closed. (5) and then turn the tap water, to see whether there is water out from the water pipe is connected. If out of the water, the water is slightly; if no water appears, proved to be a serious shortage. "Waters" process can be repeated several times but not delay too long, so the expansion of the accident. "Waters" principles of operation are: After draining cock open, then close the steam, the water pipe connected between the water cock and the table, so that a large vapor communication with the water table, water gauge pressure is zero. Then again closed drain cocks open water pipe connected between the water cock and the water table, because the pressure within the drum water level higher than the inner pressure table, if the drum water level is in the vicinity of the water pipe connected to the water vapor stream is brought into water table, which shows the extent of water shortage is not serious. If the "waters" has never been in the water table level, water is considered more serious.
The use of low nitrogen condensing gas 20 ton h fire tube boilers What are the advantages?
1, capacity scalability good
Fang fast low nitrogen 20 ton h fire tube boiler why coverage is so high in the market: energy and the environment has been the primary problem to be solved in our country, but also China and adhere to the road of sustainable development challenges must be faced. Boiler as social and economic life of thermal power equipment essential for the development of all walks of life are inseparable from it. At the same time, the boiler emissions of smoke and other substances also increased atmospheric pollution burden, reduce emissions of harmful substances boiler, without delay.
As one of Beijing's air pollution emission standards of the most demanding urban, environmental control is very strict. Beijing primary school campus Emerald City as one of the cradles of socialist culture successor, in terms of the quality of students' learning environment is put emphasis on one hundred percent. October 2017, Beijing primary school campus Emerald City with my company, signed a two Thalia T6 series vacuum hot water 20 ton h fire tube boiler for winter heating use.
